I had previously removed the W126 cowl covers to clean the drains. Now they are clean and I have replaced the ABS module bracket, they were ready to be re-installed. Before I did so, I had some new parts to install. The first were the rubber boots that cover the windscreen wiper shafts. On most W126 cars they are almost non existent. On my...
As part of the installation of the Monovalve elimination kit, I needed to remove the ABS controller bracket. The bracket was in the way of the coolant hoses. I order to remove it, I needed to remove the W126 cowl drains cover. This is great opportunity to inspect this area and clean it. Cars that have parked outside often have debris here that causes...
While I was replacing the fuel pump on my E-Type I noticed some hairline cracks in the fuel hoses. This was obviously a problem waiting to happen so I ordered a new set to replace them. It is probably cheaper to buy the raw hose and adapt the original fittings, but SNG Barratt sell a kit with new hoses complete with fittings that is...
I have been working on a project to eliminate the monovalve from the climate control system in my 560SEC. In the last part I had almost completed the cooling hoses required for the job. I had mostly worked out hose routing I was looking for – which was combining the dual outputs from the heater core into a single hose where I could place...
A few friends in the Mercedes Club and I have been trying to get a monthly night drive going. Last night was the third one and yet again we had a great drive. This time we met up in Kirrawee and the drive was through the national park to Bulli. We started out with 5 cars and based on the cars that participated,...
The Mercedes Club hold a mid-week drive pretty much every month. I’ve been a member for more than 10 years but never managed to attend one. I had a free day today and the drive looked really good. This months MBCNSW mid-week drive was up to the Hunter valley. The route was via the Putty road, which I’ve done a few times before. Mid-week...
My 560SEC has been leaking from the power steering and self leveling suspension. In both cases, it is obvious that (at least some) of the leakage is coming from the low pressure hydraulic hoses. It is possible there are additional leaks in the steering, but fixing this obvious one is a good place to start. I had looked at doing this job...
As part of the work I have been doing to the 560SEC, I have removed the radiator. The radiator was leaking from the top tank and appeared to be original. It was an IMI unit which was one of the OE suppliers and had a 1987 date code on it. W126 radiator removal is fairly straightforward. Fist step is obviously draining the coolant,...
My 560SEC had been leaking coolant and giving me heat when I didn’t want it. Last week I started the repairs for these problems. As the Bosch and Mercedes W126 Monovalve repair kit was no longer available, I have been installing the Klima Design Works monovalve elimination kit. In the first part I removed the W126 monovalve, auxiliary water pump and other hoses. This...
My 560SEC has been having a couple of problems with its cooling system. Coolant has been weeping out of the top tank of the radiator. In addition, the monovalve has failed, causing unwanted heating at idle. The radiator looks either original or replaced very early in the cars life. As these radiators have plastic tanks, I have purchased a new one to replace it....
I’m a member of a few different car clubs (Mercedes, Jaguar, Citroen), but am rarely able to make events. With a young family the times rarely work for me. A lot of the time I spend either working on or driving my cars is late at night. I figured I am not the only one in this situation, so after a poll of a...
A couple of months back, I noticed a bad fuel smell from my E-Type. I was able to trace the problem to a leaking E-Type fuel pump. The car still had the original points type SU pump, which are rebuildable. After speaking to a few people, and doing some research, I decided to purchase a new pump. The new SU pumps are a solid...
The R/C107 models had an extremely long production run – 18 years. There were a variety of different models and specification changes. This included the differential ratios that can have a big impact on the performance and economy of the vehicle. In compiling the table below, I have tried to research the various country specific variants. It is possible I have missed a few. ...
In April 1982 Mercedes-Benz was pretty much king of the hill when it came to mainstream luxury cars. Rolls Royce was in a league of its own, and Jaguar was at its quality nadir. BMW were just releasing the E30 which would propel them to a leadership position in the small, luxury market. They still could not touch Mercedes-Benz in the mid or upper...
I recently came across a price list from Yorkstar Motors, dated December 1969. Yorkstar motors were at that time the main dealer in Sydney and I think they had something to do with the overall importation of the cars. This era Australian delivery cars have a Yorkstar motors tag on them regardless of where they were sold. Unlike in later years, nearly the whole...
Today I joined an event with the MBCNSW for a drive to Bilpin. Bilpin is to the West of Sydney and is half way up the Blue Mountains. It is know for its Apples. The purpose of the drive was to raise money for one of our club members, Sam. Sam is the proprietor of the Bilpin Apple Pie Cottage, our destination. He suffered...
More Posts
